Manual sidewall Roll Up Winches

redpath nz
redpath nz
redpath nz
redpath nz
r
redpath nz
redpath nz
redpath nz
redpath nz

Eziwinder - "roll-up-wall" manual winch system

The Redpath self-locking Eziwinder roll up wall winch is simple to install, easy to operate and a cost-effective sidewall ventilation system. A roll up wall system will supply substantial control over the internal environment and may be adapted to most building designs.

The Eziwinder winch incorporates a unique self-locking all metal gearbox that will lock the roll up wall in the position that the operator requires. Simply turn the handle and the 5:1 reduction ratio allows easy winding of the up to 50m length roll up wall.

A steel round guide tube (25.4mm OD) is located vertically through the roller guide of the winch itself and may be purchased as a separate part if you do not have this.

The roll up wall tube that runs the length of the wall horizontally and is turned by the Eziwinder winch to winder the wall up is a 33mm O/D steel tube section; lengths are as shown below, - order as many as required for your length wall.  The tube is "swaged" at one end so that it may sleeve together, small 'wafer head" screws (four per join) will be needed to lock the joints together.

For taller greenhouses the chain drive Eziwinder is also available. Using the same self-locking gearbox as the standard winder, the chain Eziwinder allows you to open your side wall to its full opening point giving you maximum ventilation.

The other part of the roll up wall system is the "Poly clamp" grips - that secure the roll up wall material to the rolling pipe. (Allow a minimum of one Poly clamp per metre)

Redpath recommend Polyweave reinforced greenhouse film for the roll up wall sheeting (click here)  + Vent-net (click here) wall screening for the outer barrier netting may be used to hold the roll up wall against the greenhouse poles. If Vent-net is not used then some Poly belt webbed strapping will be needed to keep the roll up wall tight against the poles of the building.

 Click here to view Installation instructions pdf

Call free on 1 800 024 680 or use the form below for more information 

Enquire now

Eziwinder Roll Up Hand Winch 5:1 Zinc complete $117.13

Roll Up Guide Tube 3.8m long, 25.4 diameter $26.40

Swaged roll up wall tube 25nb x 2mm x 6.5m $57.20

Polyclamp for Roll Up Walls - each $0.99

Polybelt White 25mm x 50m webbed strap $50.60

Eziwinder Roll Up Hand Winch 5:1 Zinc complete with Chain $156.85